|
05-13-2020, 04:38 PM
|
#1
|
Senior Member
Join Date: Apr 2015
Location: Western New York
Posts: 605
|
Power Jack Issue
My power jack (FIC 3500) will not go up, but it will go down. LED night light works. I used the manual wrench, it goes up with no restriction.
I inspected the switch, looks clean, all connections good. I was going to reverse the wires to see if it would go down but all the wire are soldered to the switch.
I assume its a bad switch, but before I take it apart I would like some feedback if anyone has had the same issue.
Thanks!
__________________
2015 Jayco Jayflight 27RLS
2012 Ford F-150
2001 Fleetwood Terry 28x
1996 Viking Pop-up
1979 Coleman 8 man cabin tent
1967 G.I Joe (hasbro) canvas pup tent
|
|
|
05-13-2020, 06:12 PM
|
#2
|
Senior Member
Join Date: Oct 2014
Location: Sparwood, BC
Posts: 2,800
|
Did you have the power jack covered? Water doesn't mix with electrical. You can bypass the switch with some extra wiring and connect the motor directly to the battery and reverse for up and down. That way you can isolate if the switch as problem.
__________________
2014 Ram 1500 CrewCab 4x4 5.7 Hemi 3.92 Rear and Air Lift 1000
2005 Jayco Jay Feather LGT - 29Y GVWR-7000 lbs.
Dexter Axle Lift 4-9/16" - installed with sub-frame.
Pro Series 1200 lbs. WDH with Double Sway Bar.
Champion 3100/2800 watt Inverter/Generator-Onboard Solar Power
|
|
|
05-13-2020, 07:01 PM
|
#3
|
Site Team
Join Date: Apr 2012
Location: Newark, NY
Posts: 15,931
|
My money's on the switch, also. Part number(?) "A" in the replacement parts page.
http://www.fastecindustrial.com/amkt...STRUCTIONS.pdf
__________________
Moderator
Think you're too old to cry or swear out loud...walk into your hitch in the dark.
2012 Jay Flight 19RD
2016 Ford F150 XLT 2X4 SC 3.5L Eco Max Tow
2010 Tundra TRD DBL Cab (Traded)
2 new fluffy Corgis, Bayley and Stanley
|
|
|
05-13-2020, 07:01 PM
|
#4
|
Site Team
Join Date: Apr 2012
Location: Newark, NY
Posts: 15,931
|
My money's on the switch, also. Part number(?) "A" in the replacement parts page.
http://www.fastecindustrial.com/amkt...STRUCTIONS.pdf
And the switch with an actual number.
ttps://www.wescofastec.com/product-p...-down-switch-1
__________________
Moderator
Think you're too old to cry or swear out loud...walk into your hitch in the dark.
2012 Jay Flight 19RD
2016 Ford F150 XLT 2X4 SC 3.5L Eco Max Tow
2010 Tundra TRD DBL Cab (Traded)
2 new fluffy Corgis, Bayley and Stanley
|
|
|
05-13-2020, 07:27 PM
|
#5
|
Senior Member
Join Date: Apr 2015
Location: Western New York
Posts: 605
|
Quote:
Originally Posted by JFlightRisk
|
JFlightRisk, you're my hero! Thank you!
__________________
2015 Jayco Jayflight 27RLS
2012 Ford F-150
2001 Fleetwood Terry 28x
1996 Viking Pop-up
1979 Coleman 8 man cabin tent
1967 G.I Joe (hasbro) canvas pup tent
|
|
|
05-13-2020, 08:22 PM
|
#6
|
Site Team
Join Date: Apr 2012
Location: Newark, NY
Posts: 15,931
|
You're most welcome Meeker. If you buy two, you'll never need the second one. Ever...
__________________
Moderator
Think you're too old to cry or swear out loud...walk into your hitch in the dark.
2012 Jay Flight 19RD
2016 Ford F150 XLT 2X4 SC 3.5L Eco Max Tow
2010 Tundra TRD DBL Cab (Traded)
2 new fluffy Corgis, Bayley and Stanley
|
|
|
05-14-2020, 10:10 AM
|
#7
|
Senior Member
Join Date: Jul 2016
Location: Mapleton
Posts: 4,377
|
My led would also work but not the motor. I finally traced it down to no ground. The bolts holding to the frame just were not grounding fully. The LED uses a tiny bit of power but when I hit the switch not enough. I finally ran a dedicated ground wire from a cleaned off spot on my jack base to the battery. Never had a problem since!
Jump over the switch if you can. If it runs it is the switch, if not check the ground and the positive wire.
__________________
2017 SLX 195RB
2021 Jeep Grand Cherokee Summit L 5.7L V8
Andersen WDH hitch, Renogy 100 AH Lithium &
200 Watts solar panels from Renogy
Prev. '14 Jeep Grand Cherokee Overland, gas 3.6 V6
|
|
|
05-14-2020, 07:12 PM
|
#8
|
Senior Member
Join Date: Feb 2015
Location: Winnipeg
Posts: 942
|
The problem I had with mine is that the battery contacts were corroded enough that not enough amps were getting through for the motor. The light was working, though. Some emery cloth to clean up the contacts and battery posts solved the problem.
__________________
Geoff & Jill
& Sierra, the little white monster
2013 Ford F-150 XTR SC Ecoboost
2015 Jayco Jay Flight 24FBS
Winnipeg, Manitoba
|
|
|
05-14-2020, 07:37 PM
|
#9
|
Senior Member
Join Date: Apr 2015
Location: Western New York
Posts: 605
|
Roger and North, thanks for your feedback.
My battery terminals are clean as a whistle. I did check the ground bolted to the frame, a little corrosion, I cleaned it and reconnected, still no luck in going up. Motor works going down. I ordered a new switch thanks to JFlightRisk's help. I will let you know if that solves the problem.
"I love you guys!"
__________________
2015 Jayco Jayflight 27RLS
2012 Ford F-150
2001 Fleetwood Terry 28x
1996 Viking Pop-up
1979 Coleman 8 man cabin tent
1967 G.I Joe (hasbro) canvas pup tent
|
|
|
05-14-2020, 08:26 PM
|
#10
|
Senior Member
Join Date: Sep 2017
Location: Edgewater
Posts: 392
|
While not totally connected but related. Folks should check the inline fuse regularly. The holder isn't really even water resistant. I ended up replacing mine with one from a boat store. The spring had badly rusted and only enough power for the LED light got through.
Just one more thing to check.
__________________
Jim Davis
2018 Hummingbird 17RK
Toyota Highlander
|
|
|
|
Posting Rules
|
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts
HTML code is Off
|
|
|
|
» Recent Threads |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|