Jayco RV Owners Forum
 


Reply
 
Thread Tools Display Modes
 
Old 09-05-2016, 04:09 PM   #1
Junior Member
 
Join Date: Aug 2016
Location: Freedom
Posts: 1
Delamination

Hello I have a 2015 Jay Feather Ultra Lite X19 H. We have Delamination on the bottom 3" or so on the bottom exterior of the bunk end. Would this be a warranty issue and should I be concerned about it?
__________________

Capecodstriper is offline   Reply With Quote
Old 09-05-2016, 04:16 PM   #2
Senior Member
 
Join Date: Nov 2015
Posts: 1,036
Delamination is commonly caused by water intrusion and warranty should be applied.
__________________

abarkl is offline   Reply With Quote
Old 09-05-2016, 05:06 PM   #3
Member
 
Join Date: Jul 2014
Location: Boaz
Posts: 47
If it is still under warranty, yes, this would be a warranty issue. Best to have it fixed at Jayco's expense, rather than your own after warranty expires. We just went through this with our 16XRB. The plastic trim, where the canvas attaches to the trailer, was cracked and allowing water in when it would rain while opened. This caused the bunk door to start delaminating around the edges. We took it to our dealer, they inspected it, took pictures of the damage, and submitted a claim to Jayco. Jayco paid them, and provided replacement parts, to completely replace the canvas, bunk door, and all seals. This would have been an expensive, major repair, had we paid out of pocket for it ourselves.

David
astrowolf67 is offline   Reply With Quote
Old 09-06-2016, 06:13 PM   #4
Junior Member
 
Join Date: Sep 2016
Location: Burleson
Posts: 29
As the others have said, YES.

I'm doing work on mine now and it is no fun and not cheap. . Thankfully I have the skills to do it because it would have cost in excess of $3000 per a couple of estimates.
__________________
Scott
2007 19H
Scott91370 is offline   Reply With Quote
Old 09-10-2016, 08:23 PM   #5
Member
 
Join Date: Sep 2010
Location: Boonville,Mo
Posts: 84
Yes, get it fixed while still under warranty. Water intrusion is a possibility but it could also be caused by a laminate bonding problem we encountered on the front cap of our 2015 Whitehawk 29REKS. The adhesive that was used for bonding the laminate failed and caused delamination along the edges of the cap. I thought it was water intrusion but that wasn't the cause. Anyway the front cap was replaced under warranty so get yours looked at ASAP
__________________
[SIGPIC]
2015 29 REKS
Quick Step is offline   Reply With Quote
Old 09-11-2016, 04:55 PM   #6
Senior Member
 
Cosmik Debris's Avatar
 
Join Date: Aug 2013
Location: Missoula, Montana
Posts: 520
My 2013 Eagle 5th wheel had delam beginning on back wall just at the 2 year point. Jayco sent entire new wall to dealer who did the work. Was able to delay it until done with planned trips and they had it about a week. I had then leave off all decals, which they seemed fine with.
__________________
"I might be movin' to Montana soon..."

2013 Eagle 29.5RKS
2013 Ford 6.7L diesel F350
Cosmik Debris is offline   Reply With Quote
Old 09-11-2016, 05:07 PM   #7
Member
 
Join Date: Sep 2014
Location: S. Central UP
Posts: 50
Same problem on my 2015 eagle. Back wall problems. The dealer had to order the back wall and said when the season was over they would install it under warranty.
__________________

rbintheup is offline   Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off


» Virginia State Campgrounds

Reviews provided by

Powered by vBadvanced CMPS v3.2.3

All times are GMT -6. The time now is 10:26 AM.


Powered by vBulletin® Version 3.8.8 Beta 1
Copyright ©2000 - 2017, vBulletin Solutions, Inc.
Copyright 2002-2016 Social Knowledge, LLC All Rights Reserved.